Sauk Valley Aviation Maintenance (815-213-7939)

ANNUAL INSPECTIONS 

100 HOUR INSPECTIONS

CONDITIONAL INSPECTIONS  "EXPERIMENTALS"

50 HOUR INSPECTIONS: ENGINE OIL & OIL FILTER INSPECTION 

CHAMPION OIL FILTERS 

PHILLIPS & AEROSHELL AVIATION OIL

OIL ANALYSIS   "BLACK STONE"

MAJOR & MINOR ALTERATIONS

MAJOR & MINOR REPAIRS

Experience with Installation of Electronic International, & JPI Electronic Engine Monitors and Gauges.

• REMOVE AIRFRAME INSPECTION PANELS, INSPECT AIRFRAME, REINSTALL INSPECTION PANELS
• SERVICE WHEEL BEARINGS
• SERVICE LANDING GEAR
• GEAR SWING OPERATIONAL CHECK
• SERVICE BRAKES
• LUBRICATE AIRFRAME
• SERVICE AND TEST BATTERY
• CHECK ELT OPERATION
• REMOVE ENGINE COWLING
• ENGINE CYLINDER COMPRESSION TEST
• DRAIN AND REFILL ENGINE OIL   *OPTIONAL  BLACKSTONE OIL ANALYSIS
• REMOVE, INSPECT, AND INSTALL NEW OIL FILTER
• CLEAN AND INSPECT SPARK PLUGS
• CHECK MAGNETOS
• SERVICE FUEL FILTER
• SERVICE AIR INTAKE FILTER
• CHECK INTERIOR AND EXTERIOR LIGHTS
• POST INSPECTION OPERATION CHECKS
• AD RESEARCH UP TO 1 hr.
• * AD COMPLIANCES ARE EXTRA

Annual inspection fees quoted are on a flat rate basis and quoted per hour for each plane. All parts will be charged an extra fee, for example, oil and filters will be above the flat rate for the annual. Also any defects found during the inspection that require repair would be charged at our shop rate of $85.00 per hour plus parts and supplies.

If you're getting quotes that are significantly lower for less hours, be aware that not receiving a full inspection will cost you a bit more money down the road.

Sauk Valley Aviation Maintenance will call with estimates for any repairs, if needed, prior to completing any work.

We can install your engine pre-heater.

Call to find out the facts of engine pre-heaters.

All certified Brands Installed

REIFF,  TANNIS,  EZ-HEAT

We do  selected experimental aircraft conditional inspections